Illustrated Physics
physics, drawn
Concept

Lubrication — where it appears

The separation of two sliding or approaching surfaces by a thin film of fluid, whose pressure carries the load. In a converging gap or a squeezed film the viscous pressure rises as the inverse cube of the gap, which is how journal bearings float and wet surfaces resist closing.

Named by 2 essays across one field — each of them below, with the objects they name alongside it.

The pressure at which an oil becomes a glass. Viscosity against pressure for 4 liquids on a logarithmic axis, from Barus's rule with the pressure coefficient each one actually has. The rule is an exponential, so a gigapascal multiplies an ordinary oil's viscosity by a hundred million or more, and the curves cross the line conventionally taken to mark a glass — a million million pascal-seconds — at 1.37 GPa for a mineral oil, 0.98 GPa for a traction fluid. The vertical line is the peak pressure inside the loaded contact this figure is about, 1.32 gigapascals, computed from the Hertz solution for that geometry and load. Water is drawn for contrast: its pressure coefficient is thirty times smaller, it never approaches a glass over this range, and that is why it is useless as a lubricant in a rolling contact however clean it is. Each curve is drawn solid up to the glass line and dashed above it, because past that point the material is not a liquid and its viscosity is not what decides how it shears — the exponential continues, and the substance it was written for does not.

The oil that is a glass for a quarter of a millisecond

Every other account of viscosity here varies the temperature. Pressure does something larger and in the same direction for every liquid: viscosity rises exponentially, by a factor of ten to the eight or more at the gigapascal inside a loaded gear tooth. That is not a curiosity — it is the only reason there is a film there at all. Remove the pressure dependence from the calculation and the predicted film is five nanometres, under the roughness, and the surfaces touch.

fluids · Viscosity The suction that holds two wet plates together. The force needed to pull apart two discs 10 cm across, starting 10 micrometres apart with water between them, at constant opening speeds of 1, 10 and 100 micrometres a second, against time; the dashed line is the largest suction the water can transmit, ½πR²pₐₜₘ = 398 N, reached when the pressure at the centre falls to zero and the water cavitates. At 1 µm/s the force starts at 29.5 N and falls as the cube of the widening gap, to 10.7 N after four seconds, when the gap is 14 micrometres. At 100 µm/s the viscous law would demand 2.9 kN; the water cannot pull that hard, and the force sits on the cavitation limit until the gap has opened enough for the viscous suction to fall below it.

The wet plates that hold on when pulled

Lift a wet glass plate straight up off another and it resists with a force far beyond its weight; slide it sideways and it comes away at a touch. The grip is not surface tension. It is the water that must rush into the widening gap, and the suction it takes to draw it in grows as the inverse cube of the gap — until the water tears open and the atmosphere sets the limit. The same cube makes a flat base float on a wet table where a ball would settle, and gives a micro-machined accelerometer exactly the damping it needs from a few micrometres of air.

fluids · Viscosity

Named alongside it

The objects these essays reach for when they reach for this one.

ViscosityCavitationContact mechanicsDampingElasticityExponentialExtrapolationFree volumeFrictionGlass transitionNegative pressurePoiseuille flow

All concepts